Pipeline soda mixed heater

I. Overview 1, soft drinks mixed heater is a new type of vapor-liquid mixing heating device, compared with other heat transfer equipment, it has a high heat transfer efficiency, low noise, easy installation, low cost and so on. It is widely used in the production, domestic water heating and hot water heating systems. 2, the product structure shown in Figure 1, when the work was drawing the heated water through the valve Seoul tubular nozzle, steam is injected into the water from the nozzle side by a lot of diagonal holes on the wall, both in high-speed Good mix of instantaneous flow, achieve the purpose of heating water. Second, the installation and commissioning 1, the heater can be installed horizontally or vertically installed, but the steam is injected into a horizontal or downward direction only. 2, near a heater at the steam pipes, you need to install check valves, filters. Such as a system with the circulation pump cycle power, it is best to install the solenoid valve in the steam pipe, so that the steam can automatically cut off when the power source. 3. When you start, you should open the valve, after opening the steam valve. When you stop running, you should turn off the steam valve, close the valve after. Third, use: where the need to mention the use of the steam temperature of the occasion, you can use soda mixed heater. For example: 1. heating and hot water preparation. 2. Plant raw water heating and recycling low-pressure exhaust steam deaerator heating demineralized water. 3. The chemical, petroleum, light industry recover low-pressure exhaust steam, used to produce hot water. 4. Living hospitals, hotels, and other residents with hot water baths and hot water system. While their heating can be divided into one-way open system and circulatory system. (A) one-way open system (one heated) one after heating, hot water directly to the tub, baths and other occasions by domestic water heater, called a one-way open system. Single open system, when it is not introduced into the steam flow through soda mixed heater standard friction loss of five meters of water, after steaming, the friction loss is zero. (B) the circulatory system (hydronic) as reaction tank liquid heating, swimming pool heating, etc are circulating loop heating system. In hydronic heating system, circulating water is heated to a maximum temperature, than the temperature of saturated steam at the same pressure of the lower 10 ℃. Circulating water loss through friction soda mixed heater a maximum of 3 meters of water. Fourth, the design, ordering pay attention to design issues, the order should provide the following technical parameters in order to choose the right soft drinks mixed heater. a: vapor pressure (gauge pressure) and temperature. b: water pressure (gauge pressure), flow rate and the initial temperature. c: the water pressure (gauge pressure) and temperature. d: is the system still used for open or closed loop system for the water treatment system. e: installation, that is mounted horizontally or vertically. f: with what occasions and for what purposes, whether the corrosive liquid, is to be equipped with temperature control system, material selection and so on. Five Advantages: soda mixed heater belonging to the direct heat transfer equipment, plate heat exchangers, heat exchangers, radiators and other equipment belonging to the indirect heat exchanger. Advantages soda mixed heater are: 1. vapor and liquid instant mixing, heating rapidly, up to 100% thermal efficiency, energy saving. 2. soda mixed steam pressure lower, higher by heating the liquid pressure can be used, regardless of the vapor pressure of the liquid pressure must be higher than the limit of 0.05 ~ 0.1Mpa. 3. vibration and low noise. 4. Small, cheaper prices ,, less investment. 5. Large temperature, up to 70 ℃. 6. Simple structure, removable, easy to scale, maintenance-free, long life. 7. Industrial low pressure waste steam as a heat source hot water, saving energy and protecting the environment. 8. As the use of model parameters or specially designed for the user, the user has a strong applicability, smooth operation, to meet user requirements. Sixth, the performance characteristics: soft drinks mixed heater, implements start without shock, vibration-free operation, minimal noise, even in the case is equipped with automatic temperature control system, still running smoothly.